CHAPTER ONE: GENERAL INFORMATION
Manual Organization | Warnings, Cautions, and Notes | Safety | Serial Numbers | Fasteners | Shop Supplies | Basic Tools | Precision Measuring Tools | Electrical Fundamentals | Basic Service Methods | Storage

CHAPTER TWO: TROUBLESHOOTING
Operating Requirements | Starting The Engine | Starting Difficulties | Engine Performance | Engine Noises | Engine Lubrication | Cylinder Leakdown Test | Clutch | Transmission | Final Drive | Electrical Testing | Lighting System | Starting System | Charging System | Ignition System | Front Suspension and Steering | Brake System

CHAPTER THREE: LUBRICATION, MAINTENANCE and TUNE-UP
Fuel Type | Pre-Ride Check List | Tires and Wheels | Battery | Engine Oil and Filter | Transmission | Final Drive | Control Cable Service | Rear Brake Pedal Pivot Shaft Bolt and Bushing Lubrication | Shift LeverCleaning and Lubrication | Sidestand | Windshield Adjust Shaft (RS Models) | Air Filter | Brake System | Clutch | Fuel Filter Replacement | Fuel Hose Inspection | Crankcase Breather Inspection | Evaporative Emission Control System | Exhaust System | Handlebars | Handlebar Grips | Front Suspension Inspection | Rear Suspension Inspection | Rear Frame Inspection | Fastener Inspection | Tune-Up Procedures | Cylinder Head Fasteners | Valve Clearance | Ignition Timing | Engine Compression Test | Spark Plugs (Single Plug Ignition System) | Spark Plugs (Dual-Plug Ignition System) | Spark Plug Inspection | Throttle And Choke Cable Adjustment (All Models Except R850C and 1200C Models) | Throttle Cable Adjustment (1993-1995 R850C and R1200C Models) | Throttle Body Synchronization and Idle Speed Adjustment | Alternator Drive Belt Adjustment

CHAPTER FOUR: ENGINE TOP END
Engine Service Notes | Cylinder Head Cover | Cylinder Head | Valve Gear Holder | Valves and Valve Components | Cylinder and Piston | Piston and Piston Rings

CHAPTER FIVE: ENGINE LOWER END
Engine Service Notes | Servicing The Engine In Frame | Engine (GS, R, RS and RT Models) | Engine (R1100S Models) | Engine (R850C and R1200C Models) | Alternator Support Cover | Auxiliary Drive Shaft Mechanism | Oil Pump | Crankcase | Rear Main Seal Replacement | Auxiliary Drive Shaft, Camshaft Chains and Tensioner Assemblies | Crankshaft | Connecting Rods | Oil Coolers and Hoses | Engine Break-In

CHAPTER SIX: CLUTCH
Clutch | Clutch Release Mechanism (Cable Operated Models) | Clutch Cable | Clutch Master Cylinder | Clutch Release Cylinder | Clutch System Hydraulic

CHAPTER SEVEN: FIVE-SPEED TRANSMISSION and GEARSHIFT MECHANISMS
Transmission Case | Neutral Switch and Gear Position Switch | Transmission Housing Cover | Transmission Shafts and Gearshift Mechanism | Transmission Shafts | Gearshift Mechanism | Transmission Housing, Housing Cover Bearings and Seals

CHAPTER EIGHT: SIX-SPEED TRANSMISSION and GEARSHIFT MECHANISMS
Transmission Case | Neutral | Gear Position Switch | Transmission Housing | Transmission Shafts and Gearshift Mechanism | Transmission Housing and Housing Cover | Transmission Shafts | Gearshift Mechanism | Transmission Housing and Housing Cover Oil Seals

CHAPTER NINE: FUEL, EMISSION CONTROL and EXHAUST SYSTEMS
Motronic System | Fuel Injection System Components | Depressurizing The Fuel System | Fuel Injection System Precautions | Fuel Injectors | Throttle Body | Pressure Regulator | Motronic Control Unit | Throttle Position Sensor | Air Filter Assembly | Throttle Cables | Increase Idle (Choke) | Cable Replacement (All Models Except R850C and R1200C) | Fuel Tank | Rollover Valve (All R1150 Models) | Fuel Filter Replacement | Fuel Pump | Fuel Pump Pressure Test | Fuel Level Sending Unit | Crankcase Breather System (U.S. Models Only) | Evaporative Emission Control System (California Models Only) | Exhaust System

CHAPTER TEN: ELECTRICAL SYSTEM
Electrical Component Replacement | Charging System | Alternator | Ignition System | Hall Sensor Unit | Main Ignition Coil | Direct Ignition Coils | Spark Plug Secondary Wires | Spark Plug Primary Wires (Dual-Plug Models) | Starting System | Starter | Starter Relay | Lighting System | Headlight | Taillight | Brake Light And License Plate Light | Turn Signals | Switches | Rider Information Display (RID) (1993-1998 GS, RS and RT Models) | Instrument Panel | Central Electrical Equipment Box or Modules | Relays | Fuses | Battery Case | Horn | Wiring Diagrams

CHAPTER ELEVEN: WHEELS, HUBS and TIRES
Front Wheel | Rear Wheel | Front Hub | Wheel Runout And Balance | Spoke Wheel Service | Tire Changing | Tire Repairs

CHAPTER TWELVE: FRONT SUSPENSION and STEERING
Handlebar | Handlebar Controls | Handlebar Lever | Clearance Adjustment (R1100S and All R1150 Models) | Upper Fork Bridge | Lower Fork Bridge | Front Fork (GS, R, RS and RT) | Front Fork (R1100S) | Front Fork (R850C and R1200C) | Front Fork Overhaul (All Models) | Front Strut Adjustments | Front Strut | Front Suspension A-Arm | Steering Damper (R1100R Models)

CHAPTER THIRTEEN: REAR SUSPENSION and FINAL DRIVE
Shock Absorber | Swing Arm and Drive Shaft (Paralever Models) | Final Drive Unit (Paralever Models) | Swing Arm and Drive Shaft (Monolever Models) | Final Drive Unit (Monolever Models) | Final Drive Overhaul (All Models) | Pinion Gear-To-Ring Gear Adjustment (All Models) | Tapered Roller Bearing Preload

CHAPTER FOURTEEN: BRAKES
Brake Fluid Selection | Preventing Brake Fluid Damage | Brake Service | ABS II System | Integral ABS System | Brake Pads | Brake Calipers | Caliper Overhaul | Brake Fluid Filler Adapter | Front Master Cylinder (R850R and All R1100 Except R1100S) | Front Master Cylinder (R850S, R1100S, R1150 and R1200C) | Rear Master Cylinder | Brake Disc and Sensor Wheel | ABS Sensor | ABS Unit (ABS II Models) | ABS Pressure Modulator (Integral ABS Models) | ABS Relay (ABS II) | Brake Hose and Line Replacement | Rear Brake Pedal | Brake Bleeding (Non-ABS and ABSII Models) | Brake Bleeding (Integral ABS Models)

CHAPTER FIFTEEN: BODY and FRAME
Seat | Seat Backrest (R850C and R1200C Models) | Front Fender and Mud Guard | Rear Fender and Mud Guard | Body Side Panels (R Models) | Windshield (GS Models) | Body Panels (RS Models) | Body Panels (RT Models) | Body Panels (R1100S Models) | Luggage And Luggage Carrier | Windshield Cleaning (All Models) | Sidestand | Centerstand | Footrests (R1100GS, R1100R and R1100RS Models) | Footrests (R1150R and R1150RS Models) | Footrests (R1150GS Models) | Footrest (RT Models) | Footrests (R1100S Models) | Footrests (R850C and R1200C Models) | Front Safety Bars | Handle (RT Models) | Engine Guard | Main Frame (R1100S Models) | Front Frame (R850C and R1200C Models) | Rear Frame | Raising Rear Frame