Honda GL1800 Goldwing Manual
This Clymer motorcycle manual covers the Honda GL1800 Goldwing for the years indicated below:
Models Included are:
2001-2005 HONDA GL1800 GOLDWING
The Honda GL1800 Goldwing manual by Clymer is the best reference book for repair and service information for your Honda GL1800 Goldwing motorcycle. Every Clymer motorcycle service manual is written for the do-it-yourselfer as well as the experienced mechanic, Clymer motorcycle repair manuals are the cheapest way to keep your motorcycle running properly. Every Clymer motorcycle service manual contains hundreds of original photographs and illustrations obtained from the complete disassembly and assembly of the motorcycle covered. This, in addition to extensive research, is how Clymer repair manuals achieve an unmatched level of detail, accuracy and clarity to guide the reader through each service, troubleshooting and repair procedure.
The Honda GL1800 Goldwing manual includes the following chapter information:
QUICK REFERENCE DATA
CHAPTER ONE: GENERAL INFORMATION
Manual organization | Warnings, cautions and notes | Safety | Serial numbers | Fasteners | Shop supplies | Basic tools | Precision measuring tools | Electrical system fundamentals | Basic service methods | Storage | Specifications
CHAPTER TWO: TROUBLESHOOTING
Operating requirements | Starting the engine | Engine will not start | Engine performance | Fuel system | Engine | Engine lubrication | Cylinder leakdown test | Clutch | Gearshift linkage | Transmission | Electrical testing | Final drive | | Front suspension and steering | Brake System | Cruise control
CHAPTER THREE: LUBRICATION, MAINTENANCE AND TUNE-UP
Fuel | Tune-up | Cylinder identification and firing order | Air filter | Engine compression test | Spark plugs | Ignition timing | Valve clearance | Engine idle speed inspection | Fuel hose inspection | Throttle cable lubrication | Throttle cable operation and adjustment | Reverse operation | Clutch | Engine oil and filter | Cooling system | Crankcase breather inspection | Emission control systems | Final drive oil | Tires and wheels | Brakes | Lights and horn inspection | Sidestand switch and ignition cut-off system | Steering head bearing inspection | Front suspension inspection | Rear suspension inspection | Fasteners | Unscheduled maintenance | Specifications
CHAPTER FOUR: ENGINE TOP END
Cylinder head covers | Camshafts | Cam chains and timing sprocket | Cam chain tensioner | Cylinder head | Valves and valve components | Specifications
CHAPTER FIVE: ENGINE LOWER END
Engine service | Engine | Rear crankcase cover | Primary gears | output shaft | Output shaft | Reverse shift arm | Reverse shifter and shift drum lock arm | Crankcase | Pistons and connecting rods | Crankshaft | Oil strainer and oil pressure relief valve | Oil pump | Break-in procedure | Specifications
CHAPTER SIX: CLUTCH
Brake fluid | Preventing brake fluid damage | Clutch fluid draining | Clutch system bleeding | Clutch master cylinder | Clutch slave cylinder | Clutch cover | Clutch | Specifications
CHAPTER SEVEN: SHIFT MECHANISM AND TRANSMISSION
External shift linkage | Transmission assembly | Mainshaft | Gearshift spindle assembly | Shift forks and shift drum | Countershaft | Transmission shifting check | Specifications
CHAPTER EIGHT: FUEL INJECTION AND EMISSION CONTROL SYSTEMS
Fuel injection system precautions | Fuel and vacuum hose identification | Depressurizing the fuel system | Fuel pressure test | Fuel flow test | Fuel tank | Air filter housing | Fuel injectors | Fuel pressure reulator | Throttle body | Fuel pump | Fuel pump relay | | Baro and map sensor | Idle air control (IAC) valve | Throttle position (TP) sensor | ECM Test Harness | MIL Lamp Circuit Test | Cam pulse generator | Knock sensors | Oxygen (O2) sensors | Vehicle speed sensor (VSS) | Engine control module (ECM) | Intake air temperature (IAT) sensor | Engine idle speed adjustment | Emission control system labels | Secondary air supply system | Evaporative emission control system | Intake manifold | Malfunction indicator lamp (MIL) | Specifications
CHAPTER NINE: ELECTRICAL SYSTEM
Electrical component replacement | Electrical connectors | Battery | Charging system | Alternator | Ignition system troubleshooting | Ignition coil | | gnition pulse generator | Ignition pulse generator rotor | PGM-FI ignition relay | Bank angle sensor | Engine control module | Ignition timing | Starter | reverse system troubleshooting | Starter relay A | Starter relay B | Reverse switch | Reverse relay | Reverse shift relays | Reverse shift actuator | Reverse regulator | Reverse resistor assembly | Power control relays | Speed limiter relay | Starter | reverse motor service | Headlight | Headlight adjusters | Headlight adjusting switch | Headlight adjuster relay | Front turn signal light | Trunk brake | taillight | License plate light | Saddlebag combination light | Combination meter | Speedometer | Tachometer | Coolant temperature gauge | ECT sensor | Fuel gauge (low fuel indicator) | Fuel level sensor | Oil pressure indicator and oil pressure switch | Neutral indicator | Turn signal relay | Turn signal cancel unit | Position light relay | Open air temperature sensor | Multi-display control switch | Left panel switch | Hazard switch | Hazard switch diode | Handlebar switches | Ignition switch | Cruise control switches | Clutch switch | Front brake light switch | Rear brake light switch | Gear position switch | Sidestand switch | Horns | Relay box | Fuses | Audio system | Audio unit | Audio switch | Antenna | Headset junction cable | Speakers | Specifications
CHAPTER TEN: COOLING SYSTEM
Temperature warning system | Cooling system inspection | Cooling system hoses | water pump mechanical seal inspection | Pressure test | | Coolant reserve tank | Radiators | Cooling fans | Fan relay testing | Water pump | thermostat | Specifications
CHAPTER ELEVEN: WHEELS AND TIRES
Bike lift | Front wheel | Rear wheel | Wheel runout and balance | Front hub | Tire safety | Tire changing | Tire repairs | Specifications
CHAPTER TWELVE: FRONT SUSPENSION AND STEERING
Handlebars | Front fork | Steering head and stem | Steering bearing preload | Steering head bearing races | Specifications
CHAPTER THIRTEEN: REAR SUSPENSION AND FINAL DRIVE
Shock absorber | Suspension level relays | Suspension linkage | Swing arm | Final drive housing | Specifications
CHAPTER FOURTEEN: BRAKES
Linked brake system (LBS) | Brake fluid selection | Preventing brake fluid damage | Brake service | Brake pads | Brake calipers | Brake caliper overhaul | Front master cylinder | Rear master cylinder and rear brake pedal | Secondary master cylinder | Delay valve | Proportional control valve | Brake hose and brake pipe replacement | Brake disc | Brake bleeding service tips and tools | Brake fluid draining | Flushing the brake system | Bleeding the system | Specifications
CHAPTER FIFTEEN: ANTI-LOCK BRAKE SYSTEM
ABS service precautions | ABS troubleshooting | Wheel speed sensors | Pulser ring | ABS modulators | ABS electronic control unit (ECU) | Specifications
CHAPTER SIXTEEN: CRUISE CONTROL SYSTEM
Cruise control system components | Cruise control troubleshooting | Cruise | reverse control unit | Cruise control relays | Cruise actuator | Cruise control switches
CHAPTER SEVENTEEN: BODY COMPONENTS AND EXHAUST SYSTEM
Color label | Engine side covers | Side covers | Seat | Passenger seat back | Front fender assembly | Front fender top cover | Front fender B | Front lower fairings | Meter panel | Mirrors and front turn signals | Windshield assembly | Inner fairings | Front fairing and fairing molding | Fairing pockets | Top shelter | Rear fender A | Trunk lower cover and molding strips | Trunk | Saddlebags | Rear fender B | Saddlebag | trunk stay | Remote transmitter | Remote transmitter and circuit troubleshooting | Trunk lock control unit | Trunk actuator test | Saddlebag open switch test | Open switch diode test | Exhaust system | Body repair | Specifications
WIRING DIAGRAMS
Starting and reverse systems | Ignition, charging and cooling systems | Fuel injection | ABS system | Lighting system | Turn signal and horn systems | Combination meter | Cruise control system | Accessory and trunk lock control system | Audio system | Suspension level control system | Fuse box
The Honda GL1800 Goldwing manual by Clymer is the best reference book for repair and service information for your Honda GL1800 Goldwing motorcycle.
Publisher: Clymer Manuals - 2006
Author: Ron Wright
Binding: Paperback - 8.25 x 10.75¾ inches
Pages: 720 - Hundreds of b&w photos and illustrations
ISBN: 1599690438
The Manual Store LLC
2229 Skyline Dr
Carroll, IA 51401
U.S.A.
Toll-Free: (888)659-2953
