Kawasaki Jet Ski Manual

The Kawasaki jet ski service and repair manual applies to the following years:
1976, 1977, 1978, 1979, 1980, 1981, 1982, 1983, 1984, 1985, 1986, 1987, 1988, 1989, 1990, 1991

Models Included are:

KAWASAKI JB650 (Jet Mate)
KAWASAKI JF650TS
KAWASAKI JL650SC
KAWASAKI JS300
KAWASAKI JS300SX
KAWASAKI JS400
KAWASAKI JS440
KAWASAKI JS440SX
KAWASAKI JS550
KAWASAKI JS550SX
KAWASAKI JS650SX
KAWASAKI JS650X-2
The Kawasaki jet ski manual by Clymer is a great  reference for repair and service information. This service manual is written for the do-it-yourselfer as well as the experienced mechanic.  The repair manual contains hundreds of original photographs and illustrations obtained from the complete disassembly and assembly of the jet ski. This, in addition to extensive research, is how Clymer repair manuals achieve an unmatched level of detail.  The shop manual will guide mechanics and owners through each service, troubleshooting and repair procedure possible.

---

The Kawasaki jet ski manual includes the following chapter information:

CHAPTER ONE | GENERAL INFORMATION

CHAPTER TWO | TROUBLESHOOTING

CHAPTER THREE | LUBRICATION, MAINTENANCE AND TUNE-UP
Operational checklist | Lubrication | Fuel selection | Break in procedure | Recommended fuel mixture | Fuel mixing | Starter gear oil | Control cable lubrication | Periodic maintenance | Fuel vent check valve inspection | Oil tank vent valve | fuel filter | Flame arrester | Impeller | Rubber coupler | On-shore cooling | Steering cable adjustment | Trim cable adjustment | Throttle cable adjustment | Choke cable adjustment | Engine tune-up | Storage | Specifications

CHAPTER FOUR | ENGINE (300 CC)
Engine lubrication | Service precautions | Serial numbers | Servicing engine in hull | Engine | Engine top end | Cylinder | Piston, wrist pin and piston rings | Intake manifold and reed valve | Crankcase and crankshaft | Starter clutch | Specifications

CHAPTER FIVE | ENGINE (400 CC, 440 CC AND 550 CC)
Engine lubrication | Service precautions | Serial numbers | Servicing engine in hull | Engine | Engine top end | Cylinder | Piston, wrist pin and piston rings | Crankcase and crankshaft | Specifications

CHAPTER SIX | ENGINE (650 CC)
Engine lubrication | Service precautions | Serial numbers | Servicing engine in hull | Engine | Engine top end | Cylinder | Piston, wrist pin and piston rings | Reed valve assembly | Crankcase and crankshaft | Water drain valve | Starter reduction gear | Specifications

CHAPTER SEVEN | DRIVE TRAIN
Drive shaft | Jet pump | Reverse system | Specifications

CHAPTER EIGHT | FUEL AND EXHAUST SYSTEMS
Flame arrester | Mikuni carburetor | Keihin carburetor | Fuel pump | Fuel tank | Fuel tap | RPM limiter | Exhaust system | Exhaust system cleaning and inspection | Specifications

CHAPTER NINE | ELECTRICAL SYSTEM
Battery | Charging system | Electrical starting system | Capacitor discharge ignition CDI | Electric box | Specifications

CHAPTER TEN | OIL INJECTION SYSTEM
Oil pump service | Oil tank | Oil level gauge | Oil tank vent check valve | Oil pump | Specifications

CHAPTER ELEVEN | BILGE SYSTEM
Vacuum-type bilge system | Electric-type bilge system | Specifications

CHAPTER TWELVE | STEERING AND HULL REPAIR
Steering assembly | Hull repair | Deck frame | Specifications

INDEX

WIRING DIAGRAMS

---

Publisher: Clymer Manuals - 1992
Author: Ron Wright
Binding: Paperback - 8¼ x 10¾ inches
Pages: 590 - Hundreds of b&w photos and illustrations
ISBN: 9780892875825

---