Polaris Jet Ski Manual

The Polaris jet ski service and repair manual applies to the following years:
1996, 1997, 1998

Models Included are:

POLARIS Hurricane
POLARIS SL1050
POLARIS SL700
POLARIS SL700 Deluxe
POLARIS SL780
POLARIS SL900
POLARIS SLH
POLARIS SLT700
POLARIS SLT780
POLARIS SLTH
POLARIS SLTX
POLARIS SLXH
The Polaris jet ski manual by Clymer is a great  reference for repair and service information. This service manual is written for the do-it-yourselfer as well as the experienced mechanic.  The repair manual contains hundreds of original photographs and illustrations obtained from the complete disassembly and assembly of the jet ski. This, in addition to extensive research, is how Clymer repair manuals achieve an unmatched level of detail.  The shop manual will guide mechanics and owners through each service, troubleshooting and repair procedure possible.

---

The Polaris jet ski manual includes the following chapter information:

CHAPTER ONE | GENERAL INFORMATION

CHAPTER TWO | TROUBLESHOOTING

CHAPTER THREE | LUBRICATION, MAINTENANCE AND TUNE-UP
Service precautions and practices | Fuel and oil requirements | Pre-ride check list | Post-ride check list | Periodic lubrication | Periodic maintenance | Fuel filter | Oil filter | Water fuel separator | Oil pump adjustment | Anode | Impeller and wear ring | Thermostat and pop off valve | Battery | Tune-up | Spark plugs | Compression test check | Throttle cable adjustment | Choke cable adjustment | Choke plate alignment | Carburetor adjustment and synchronization | Specifications

CHAPTER FOUR | ENGINE
Service precautions and practices | Servicing the engine in the hull | Cylinder head | Cylinder | Piston and connecting rod | Crankcase and crankshaft | Engine removal | Engine mount plates and rubber mounts | Engine installation | Specifications

CHAPTER FIVE | DRIVE SYSTEM
Service precautions and practices | Drive system checks | Jet pump and drive shaft | Engine and jet pump alignment | Jet pump and drive shaft installation | Specifications

CHAPTER SIX | FUEL SYSTEM
Service precautions and practices | Mikuni carburetor | Keihin carburetor | Fuel pump | Fuel inlet valve | Fuel tank and delivery | Reed valves | Specifications

CHAPTER SEVEN | ELECTRICAL
Service precautions and practices | Electrical box | Flywheel cover and flywheel | Stator and flywheel housing | Starter motor | Drive unit | Ignition coil and spark plug lead test | Trigger coil test | Ignition timing | Specifications

CHAPTER EIGHT | OIL INJECTION SYSTEM
Oil reservoir assembly | Specifications

CHAPTER NINE | COOLING SYSTEM
Inspection and replacement | Maintenance | Specifications

CHAPTER TEN | STEERING SYSTEM
Steering cable | Handlebar assembly | Specifications

CHAPTER ELEVEN | OFF-SEASON STORAGE

INDEX

WIRING DIAGRAMS

---

Publisher: Clymer Manuals — 2007
Author: Jay Bogart
Binding: Paperback — 8¼ x 10¾ inches
Pages: 234 — Hundreds of b&w photos and illustrations
ISBN: 9780892877447

---