|
|
|
|
Volvo Penta Stern Drive Service and Repair ManualThis Clymer stern drive shop manual covers Volvo Penta motors for the years 2001-2004.
Models Included are:
VOLVO PENTA 30GS, 3.0 L in-line 4-cyl (135 HP) VOLVO PENTA 43GI, 4.3 L V-6 (180 HP) VOLVO PENTA 43GL, 4.3 L V-6 (160 HP) VOLVO PENTA 43GXI, 4.3 L V-6 (210 HP) VOLVO PENTA 50GI, 5.0 L V-8 (250 HP) VOLVO PENTA 50GL, 5.0 L V-8 (220 HP) VOLVO PENTA 50GXI, 5.0 L V-8 (270 HP) VOLVO PENTA 57GS, 5.7 L V-8 (225 HP) VOLVO PENTA 57GS, 5.7 L V-8 (250 HP) VOLVO PENTA 57GSI, 5.7 L V-8 (280 HP) VOLVO PENTA 57GXI, 5.7 L V-8 (320 HP) VOLVO PENTA 81GI, 8.1 L V-8 (375 HP) VOLVO PENTA 81GXI, 8.1 L V-8 (420 HP) VOLVO PENTA DPX375, 8.1 L V-8 (375 HP) VOLVO PENTA DPX420, 8.1 L V-8 (420 HP)
The Volvo Penta stern drive manual by Clymer is a great reference for repair and service information. This service manual is written for the do-it-yourselfer as well as the experienced mechanic. The repair manual contains hundreds of original photographs and illustrations obtained from the complete disassembly and assembly of the engine. This, in addition to extensive research, is how Clymer repair manuals achieve an unmatched level of detail. The shop manual will guide mechanics and owners through each service, troubleshooting and repair procedure possible.
The Volvo Penta manual includes the following chapter information:
QUICK REFERENCE DATA
CHAPTER ONE | GENERAL INFORMATION
CHAPTER TWO | TROUBLESHOOTING
CHAPTER THREE | LUBRICATION, MAINTENANCE AND TUNE-UP
CHAPTER FOUR | LAY-UP, WINTERIZING AND FITTING OUT
CHAPTER FIVE | ADJUSTMENTS Carburetor | Ignition timing | Shift cable and linkage | Throttle cable | Trim position sender and trim limit control module | Specifications
CHAPTER SIX | ENGINE Removal installation | Engine alignment | Rocker arm cover | Valve adjustment | Placing the No. 1 piston at TDC | Lifter cover | Camshaft lobe lift measurement | Cylinder head | Rocker arm and pushrod | Flywheel housing | Drive coupler | Drive plate | Flywheel | Flywheel pilot bearing | Output drive shaft, seals and bearings | Oil pan pump | Harmonic balancer | Timing gear|chain cover | Timing chain and sprockets | Balance shaft | Camshaft and lifters | Piston and connecting rod | Rear main seal and rear main seal carrier | Crankshaft | Break-in procedure | Specifications
CHAPTER SEVEN | FUEL SYSTEMS Fuel system service | Mechanical fuel pump | Low-pressure electric fuel pump | Carburetor | Electronic fuel injection (EFI) | Intake manifold | Specifications
CHAPTER EIGHT | COOLING AND EXHAUST SYSTEMS Thermostat | Recirculation pump | Seawater pump | Oil and power steering fluid cooler | Exhaust elbow | Exhaust bellow and flapper valve | Exhaust tube and flapper valve | Exhaust manifold | Specifications
CHAPTER NINE | ELECTRICAL SYSTEM Battery | Alternator | Starter motor and solenoid | Starter relay | Fuel pump relay | EFI system relay | Ignition system | Oil pressure sender | Oil pressure switch | Engine temperature sender | Engine temperature sensor | Engine overheat switch | Exhaust overheat switch | Intake air temperature sensor IAT | Throttle position sensor TPS | Idle air control motor IAC | Knock sensor | Knock sensor module | Engine control unit ECU | Warning horn replacement | Specifications
CHAPTER TEN | DRIVE UNIT Drive unit service precautions | Drive unit identification | Drive unit operation | Drive unit gear ratio | High altitude operation | Outdrive service precautions | Sacrificial anodes | Shifting and propeller rotation | Propeller | Drive unit removal and installation | Upper drive shaft housing | Universal joint | Shift housing service | Pressure and vacuum test | Specifications
CHAPTER ELEVEN | INTERMEDIATE HOUSING AND TRANSOM SHIELD | BRACKET Intermediate housing operation and inspection | Intermediate housing and suspension fork | Transom shield and mounting collar | Transom bracket | Specifications
CHAPTER TWELVE | POWER TRIM SYSTEM Trim relay | Trim switch fuse | Trim limit control module | Trim motor | Trim pump | Fluid reservoir | Fluid screen | Hydraulic pump | Relief valve | Trim cylinder | Trim hose | Trim position sender | Filling and bleeding the trim system | Specifications
CHAPTER THIRTEEN | STEERING SYSTEM Safety precautions | Mechanical (manual) steering system | Power steering system | Specifications
INDEX
COLOR WIRING DIAGRAMS
Publisher: Clymer Manuals — 2004 Author: Mark Rolling Binding: Paperback — 8¼ x 10¾ inches Pages: 676 — Hundreds of b&w photos and illustrations ISBN: 9780892878987
The Volvo Penta stern drive service and repair manual applies to the following years: 2001, 2002, 2003, 2004
|
|
|
|
|
|
|