GENERAL INFORMATION
TROUBLESHOOTING
LUBRICATION, MAINTENANCE AND TUNE-UP
Routine inspection / Pre-ride inspection / Maintenance intervals / Periodic lubrication / Engine oil and filter change / Fork oil change / Control cable lubrication / Drive chain adjustment / Air filter / Periodic maintenance / Tune-up / Valve clearance measurement adjustment / Compression test / Idle mixture / Idle speed adjustment / Carburetor synchronization / Specifications
ENGINE UPPER END
Cylinder head cover / Camshaft / Cylinder head / Valves and components / Cylinder block / Pistons, piston pins and rings / Specifications
ENGINE LOWER END
Removal installation / Primary gear / Oil pump / Oil pan and strainer / Oil level switch / Crankcase / Starter clutch assembly / Crankshaft / Connecting rods / Break-in / Specifications
CLUTCH AND PRIMARY GEAR
Clutch cover / Clutch / Clutch cable replacement / Primary gear / Specifications
TRANSMISSION AND GEARSHIFT MECHANISMS
Engine sprocket cover / Engine sprocket / Shift shaft assembly / Internal shift mechanism / Transmission gears / Shift pedal / Specifications
FUEL, EMISSION CONTROL AND EXHAUST SYSTEMS
Air filter housing / Fuel pump / Carburetor / Throttle position sensor 1996-1998 United Kingdom models / Thermoswitch Australia, Canada and 1992-1995 United Kingdom models / Solenoid valve Australia, Canada and United Kingdom models / Carburetor heater 1996-1998 United Kingdom models / Fuel level / Throttle cable / Choke starter valve cable / Fuel tank / Fuel valve / Fuel filter / Vacuum fuel pump / Evaporative emission control California models / Exhaust system / Specifications
ELECTRICAL SYSTEM
Charging system / Alternator / Voltage regulator rectifier / Ignition system / Ignition coil / Pickup coil / Ignition system diode / Spark plugs / Igniter unit / Starting system / Starter motor / Starter solenoid / Starting circuit cutoff relay / Lighting system / Switches / Wiring connectors / Electrical components / Fuses / Specifications
FRONT SUSPENSION AND STEERING
Front wheel / Front hub / Wheel balance / Handlebar / Steering head / Front fork / Specifications
REAR SUSPENSION
Rear wheel / Rear hub / Rear sprocket and coupling / Drive chain / Shock absorber / Swing arm / Specifications
BRAKES
Brake pads / Caliper / Master cylinder / Brake hose / Brake disc / Bleeding the system / Rear brake pedal / Specifications
FRAME AND BODY
Seat / Fender / Side cover and grab rails / Rear cowling and grab rails / Fairing / Footpegs / Sidestand / Frame / Specifications
INDEX
WIRING DIAGRAMS
