|
|
|
|
MerCruiser ManualThis Clymer Stern Drive manual covers the MerCruiser inboard for the years 1986-1994.
Models Included are: MerCruiser Alpha One MerCruiser Bravo One MerCruiser Bravo Two MerCruiser Bravo Three Engines covered: GM inline 4-cylinder: 2.5L (151 cid) and 3.0L (181 cid) MerCruiser inline 4-cylinder: 3.7L (224 cid) GM V6: 4.3L (262 cid) GM V8: 5.0L (305 cid), 5.7L (350 cid), 7.4L (454 cid), 8.2L (502 cid)
The MerCruiser manual by Clymer is the best owners reference book for repair and service information for your MerCruiser stern drive boat. Every MerCruiser service manual is written for the do-it-yourselfer as well as the experienced mechanic. Clymer boat repair manuals are the cheapest way to keep your MerCruiser engine running properly. Every Clymer MerCruiser service manual contains hundreds of original photographs and illustrations obtained from the complete disassembly and assembly of the boat covered. This, in addition to extensive research, is how Clymer repair manuals achieve an unmatched level of detail, accuracy and clarity to guide the owner through each service, troubleshooting and repair procedure.
The MerCruiser manual includes the following chapter information: CHAPTER ONE | GENERAL INFORMATION
CHAPTER TWO | TOOLS AND TECHNIQUES
CHAPTER THREE | TROUBLESHOOTING
CHAPTER FOUR | LUBRICATION, MAINTENANCE AND TUNE-UP
CHAPTER FIVE | LAY-UP, COOLING SYSTEM SERVICE AND FITTING OUT
CHAPTER SIX | GM INLINE ENGINES Removal installation | Valve cover | Intake exhaust manifolds | Rocker arm assemblies | Crankshaft pulley and torsional damper | Timing gear cover and seal | Camshaft | Oil pan | Oil pump | Cylinder head | Valves and valve seats | Valve lifters | Piston connecting rod assembly | Rear main oil seal | Crankshaft | Flywheel | Cylinder block | Core plug |Specifications
CHAPTER SEVEN | MERCRUISER INLINE ENGINES Removal installation | Valve cover | Intake manifold | Rocker arm assemblies | Alternator rotor|stator | Front cover, seals and circulating pump | Timing chain and sprockets | Camshaft | Oil pan pump | Cylinder head | Valves and valve seats | Valve lifters | Piston|connecting rod assembly | Crankshaft | Flywheel housing, coupler and flywheel | Cylinder block | Core plug |Specifications
CHAPTER EIGHT | GM V6 AND V8 ENGINES Removal installation | Valve covers | Intake manifold | Exhaust manifold | Rocker arms | Valve lash except Mark V big blocks and Generation II V6 engines | Crankshaft pulley and torsional damper | Crankcase front cover and oil seal | Timing chain and sprockets | Balance shaft V6 models serial No. OF000001-on | Camshaft | Oil pan pump | Cylinder head | Valves and seats | Valve lifters | Piston|connecting rod assembly | Rear main oil seal | Crankshaft | Flywheel | Cylinder block | Core plug |Specifications
CHAPTER NINE | FUEL DELIVERY SYSTEM Flame arrestor | Carburetors | Fuel pump and anti-siphon devices |Specifications
CHAPTER TEN | COOLING SYSTEM Thermostat | Engine circulating pump | Stern drive water pump | Drive belt | Cooling system maintenance |Specifications
CHAPTER ELEVEN | ELECTRICAL SYSTEMS Charging system | Direct drive alternator charging system | Starting system | Ignition system | Breaker point distribution | Thunderbolt IV ignition | DDIS ignition | EST ignition | Ignition coil | Ignition resistor wire (breaker point ignition) | Solenoids | Oil pressure switch sender unit | Water temperature sending unit | Electrical protection | Wiring harness with audio warning system |Specifications
CHAPTER TWELVE | MERCRUISER DRIVE SYSTEM Mercruiser Alpha One drive | Mercruiser Bravo One, Bravo Two and Bravo Three drive |Specifications
CHAPTER THIRTEEN | DRIVE SHAFT HOUSING Alpha One and Alpha One Generation II drive | Bravo One, Bravo Two and Bravo Three drive |Specifications
CHAPTER FOURTEEN | GEARCASE HOUSING (LOWER UNIT) Alpha One drive | Bravo One and Bravo Two drive | Bravo Three |Specifications
CHAPTER FIFTEEN | BELL HOUSING, GIMBAL BEARING AND GIMBAL RING Exhaust bellows tube | Shift cable | Gimbal bearing | Bell housing | Water hose and water tube | Gimbal ring, swivel shaft and steering lever service | Gimbal housing |Specifications
CHAPTER SIXTEEN | POWER TRIM AND TILT SYSTEMS Low-pressure pump system | Auto trim system | Trim cylinders |Specifications
CHAPTER SEVENTEEN | STEERING SYSTEMS Mechanical steering system | Power steering system |Specifications
CHAPTER EIGHTEEN | CORROSION PROTECTION SYSTEMS Zinc anodes | Continuity devices | Galvanic isolator | Mercathode system | Corrosion protection test |Specifications
INDEX
WIRING DIAGRAMS
The MerCruiser manual by Clymer is the best reference book for repair and service information for your boat.
Publisher: Clymer Manuals Binding: Paperback — 8¼ x 10¾ inches Pages: 628 — Hundreds of b&w photos and illustrations ISBN: 0892876557
MerCruiser Service and Repair Manual Applies to the Following Years: 1986, 1987, 1988, 1989, 1990, 1991, 1992, 1993, 1994
|
|
|
|
|
|
|