CHAPTER ONE | GENERAL INFORMATION
Manual organization | Warnings, cautions and notes | Safety | Serial numbers | Fasteners | Shop supplies | Basic tools | Precision measuring tools | Electrical system fundamentals | Special tools | Basic service methods | Storage

CHAPTER TWO | TROUBLESHOOTING
Operating requirements | Starting the engine | Engine performance | Starting system | Charging system | Ignition system | Fuel system | Engine noises | Engine lubrication | Clutch | Transmission | Lighting system | Excessive vibration | Front suspension and steering | Brake system

CHAPTER THREE | LUBRICATION, MAINTENANCE AND TUNE-UP
Pre-ride checklist | Tires and wheels | Battery | Engine lubrication | Fork oil | Control cables | Periodic lubrication | Air filter | Brakes | Drive chain and sprockets | Cooling system | Rear suspension | Fasteners | Tune-up

CHAPTER FOUR | ENGINE TOP END
Service precautions | Cylinder head covers | Camshafts | Camshaft chain tension and guide rails | Camshaft drive chain | Cylinder head | Valve lifters and shims | Valves and valve components | Cylinder | Pistons and piston rings

CHAPTER FIVE | ENGINE LOWER END
Servicing engine in frame | Engine | Crankcase right side cover | Crankcase left side cover | Tachometer drive mechanism | Oil pumps | Primary drive gear and camshaft drive chain | Starter clutch and gears | Crankcase, crankshaft and balancer shaft | Engine oil circuit bleeding | Engine break-in

CHAPTER SIX | CLUTCH
Clutch release lever and bearings | Clutch | Clutch service | Clutch cable replacement

CHAPTER SEVEN | TRANSMISSION AND GEARSHIFT MECHANISM
Transmission operation | Transmission | Transmission overhaul | Transmission inspection | Internal shift mechanism

CHAPTER EIGHT | FUEL, EXHAUST AND EMISSION CONTROL SYSTEMS
Carburetor operation | Carburetor | Throttle cable | Starting enrichment valve (choke) cable replacement | Fuel tank | Fuel shutoff valve | Air filter air box | Exhaust system | Crankcase breather system | Evaporative emission control system (California models) | Evaporative emission control system service | Secondary air system (U.S. and Switzerland models)

CHAPTER NINE | ELECTRICAL SYSTEM
Preliminary inspections | Battery box | Charging system | Alternator | Voltage regulator | Capacitor discharge ignition | Starting system | Starter relay replacement | Lighting system | Switches | Horn | Instruments | Fuses | Wiring diagram

CHAPTER TEN | COOLING SYSTEM
Safety precautions | Hoses and hose clamps | Cooling system inspection | Radiator and cooling fan | Cooling fan | Thermostat | Water pump

CHAPTER ELEVEN | WHEELS, HUBS, TIRES AND DRIVE CHAIN
Bike stands | Front wheel | Rear wheel | Driven sprocket and driven flange | Front and rear hubs | Wheel runout | Wheel service | Wheel balance | Tires | Tire changing | Drive sprocket and chain

CHAPTER TWELVE | FRONT SUSPENSION AND STEERING
Handlebar | Steering head | Front fork

CHAPTER THIRTEEN | REAR SUSPENSION
Shock absorber | Rear swing arm | Swing arm service | Shock linkage | Bearing replacement

CHAPTER FOURTEEN | BRAKES
Brake fluid selection | Brake service | Front brake pad replacement | Front brake caliper | Front master cylinder | Rear brake pad replacement | Rear brake caliper | Rear master cylinder | Rear brake pedal | Brake hose replacement | Brake disc | Bleeding the system

CHAPTER FIFTEEN | BODY
Seat | Front fender | Rear mudguard | Cylinder head side cover | Side cover | Engine lower cover | Windshield and front fairing | Fuel tankcover | Saddlebags | Footpegs