Kawasaki Jet Ski Manual

This Clymer Jet Ski manual covers the Kawasaki jet ski for the years 1992-1994. Models Included are:

KAWASAKI JB650 Jet Mate
KAWASAKI JF650TS
KAWASAKI JF650X2
KAWASAKI JH750 Super Sport Xi
KAWASAKI JH750SS
KAWASAKI JH750XiR
KAWASAKI JL650SC
KAWASAKI JS440SX
1992-1993 KAWASAKI JS550SX (B Models with Piston Port Engines)
KAWASAKI JS650SX
KAWASAKI JS750SX
KAWASAKI JT750ST
The Kawasaki jet ski manual by Clymer is a great  reference for repair and service information. This service manual is written for the do-it-yourselfer as well as the experienced mechanic.  The repair manual contains hundreds of original photographs and illustrations obtained from the complete disassembly and assembly of the jet ski. This, in addition to extensive research, is how Clymer repair manuals achieve an unmatched level of detail.  The shop manual will guide mechanics and owners through each service, troubleshooting and repair procedure possible.

---

The Kawasaki jet ski manual includes the following chapter information:

CHAPTER ONE | GENERAL INFORMATION

CHAPTER TWO | TROUBLESHOOTING

CHAPTER THREE | LUBRICATION, MAINTENANCE AND TUNE-UP
Operational check list | Lubrication | Recommended fuel mixture | Fuel mixing | Starter gear oil | Control cable lubrication | Periodic maintenance | Fuel vent check valve inspection | Oil tank vent valve | fuel filter | Flame arrester | Impeller | Rubber coupler | On-shore cooling | Steering cable adjustment | Trim cable adjustment | Throttle cable adjustment | Choke cable adjustment | Engine tune-up | Retorque cylinder head | Compression test | Spark plug | Ignition timing | Carburetor adjustment | Fuel mixture screw initial setting | Fuel mixture adjustment | idle speed | Carburetor synchronization | Storage | Specifications

CHAPTER FOUR | ENGINE (440 AND 550 CC)
Engine lubrication | Service precautions | Serial numbers | Servicing engine in hull | Removal installation | Engine top end | Cylinder | Piston, pin and rings | Crankcase and crankshaft | Specifications

CHAPTER FIVE | ENGINE (650 AND 750 CC)
Engine lubrication | Service precautions | Serial numbers | Servicing the engine in the hull | Engine | Engine top end | Cylinder | Piston, pin and rings | Reed valve assembly | Crankcase and crankshaft | Water drain valve | Starter reduction gear | Specifications

CHAPTER SIX | DRIVE TRAIN
Drive shaft | Jet pump | Reverse system | Specifications

CHAPTER SEVEN | FUEL AND EXHAUST SYSTEMS
Flame arrestor | Mikuni carburetor | Keihin carburetor | Fuel pump | Fuel tank | Main fuel valve | Exhaust system | Exhaust system cleaning and inspection | Specifications

CHAPTER EIGHT | ELECTRICAL SYSTEMS
Battery | Charging system | Electric starting system | Capacitor discharge ignition CDI | RPM limiter | Electric box | Bilge pump test | Bilge blower | Temperature sensor switch | Stop and start switches | Specifications

CHAPTER NINE | OIL INJECTION SYSTEM
Oil pump service | Oil tank | Oil level sensor | Oil tank check valve | Oil pump | Specifications

CHAPTER TEN | BILGE SYSTEM
Vacuum-type bilge system | Electric bilge system | Specifications

CHAPTER ELEVEN | STEERING AND HULL REPAIR
Steering assembly | Trim adjuster | Hull repair | Deck frame | Specifications

INDEX

WIRING DIAGRAMS

---

The Kawasaki jet ski service and repair manual applies to the following years:
1992, 1993, 1994

---

Publisher: Clymer Manuals
Binding: Paperback — 8¼ x 10¾ inches
Pages: 474 — Hundreds of b&w photos and illustrations
ISBN: 0892876441

---